[R-390] Will it ever be the same?

[Phil Atchley]

Hi.
Well, today I replaced the deadly capacitors in the IF strip as I wanted =
to
check out the PTO thoroughly and didn't want to risk taking out a =
mechanical
filter.  I'm going to have to wait till the first of the month to order =
all
the parts needed to re-cap this set properly, though I had enough to do
"most" of the IF strip.  (I've been working to too many BA's lately and =
ran
out of new parts).

Anyway, to make a short story long, the endpoint of this Cosmos was off =
by
about 6KHz.  I thought, aha! I should be able to pull it that far.  =
WRONG!!
I got it to where the error is about 3 KHz and I think the slug dropped =
down
into the PTO 8^((  At least that is the way it appears and the unit
"rattles" when I shake it.

SO, now I have pulled the PTO, removed the outer cover and am faced with
having to pull the entire unit apart.

I had previously downloaded a LOT (250 MB worth) of R-390 information =
and
found the two files on calibrating the Cosmos PTO.  I remember reading =
about
removing a turn from the coil, I just haven't found that "page" yet.  I
"thought" I had complete teardown/service information on this too but
haven't found it yet.  Anybody know where that info might be located?

QUESTION;  Will this poor thing ever be the same again?  I was sorry to =
see
a Cosmos PTO in this receiver and it looks like I wasn't far wrong. All =
my
personal R-390A's to date had Collins PTO's, set the end point and =
forget
it, they worked fine and were well within specs on linearity.=20

73 de Phil, KO6BB

****************************************************
*  DXing THE WORLD WITH THE FOLLOWING EQUIPMENT.   *
*  RECEIVERS:                                      *
*    '67 EAC R-390/URR Surplus Receiver with a     *
*            HAMMARLUND HC-10 Sideband adapter.    *
*    YAESU VR-5000 Wideband,  REALISTIC DX-392.    *
*    Home built Longwave "Hybrid" CW receiver.     *
*    Others which pass thru or are waiting repair. *
*  ANTENNAS:                                       *
*    Coil Loaded 18.5 Meter Long Sloper.           *
*    Roof mounted Hustler 6BTV 6 band Vertical.    *
*    Scantenna Scanner antenna at 7 Meters high.   *
*  LOCATION: Merced, Central California.           *
****************************************************




---
avast! Antivirus: Outbound message clean.
Virus Database (VPS): 6/26/2003
Tested on: 6/27/2003 12:14:06 AM
avast! is copyright (c) 2000-2003 ALWIL Software.
http://www.avast.com