[Qcwa] And now, for something entirely different.

Wed, 4 Sep 2002 09:24:24 -0400

If you only plan to use one PL freq, then the little circuit board offered
by AES and HRO and likely others would do the job.  I put one in my Drake
ML-2.  It is about one inch square, runs on 12V, and the input goes to the
varactor.  Price is about $30.  Hope it works out for you.
73, Steve N8ZR

 -----Original Message-----
From: 	JIM WILHITE [mailto:[email protected]] 
Sent:	Sunday, August 25, 2002 11:37 PM
To:	QCWAlist
Subject:	Re: [Qcwa] And now, for something entirely different.

I can't help with anything but a few stories about these kind of units, most
of which would take too much time to relate.

However, I do remember in 1976 when a sheriff's deputy from Mobitee, TX came
into a MSS in Pampa, TX to have the new Micor installed in his auto to
replace the mobile version of your unit.  It had been installed in about
1961 or so and had been moved from car to car over the years by someone in
Mobitee.  It had never been serviced and all tubes were original.  This
particular unit looked almost as new as the day it was unpacked.  The deputy
had kept it covered with a blanket and there was not a scratch on the case.

Over the years he had cleaned the control head, speaker and microphone.
They, too, looked almost new.  The unit was had crystals for 36.180 which
was the channel used by all sheriff departments throughout Texas those days.
In 1973 or so all the counties in the panhandle of Texas formed what was
called the Council of Governments which purchased a new multichannel hiband
radio system for each county giving them their own discreet frequency plus a
base to base frequency.   

There was a lot of resistance to this since all cars and base station
dispatchers listened to everything that happened in all counties.  Anyway,
the service shop put the unit on the bench and ran the receive and transmit
tests to find out the unit was still on frequency, modulating properly and
received as it should.   

Not bad for a unit of its age.

You might ask around to see if any Motorola service shops are still in
existence that were in business in the mid to late 70s.  They just might
have a manual in the attic that will cover the strips.  The PL thing will be
a different story.  Audio from the receiver strip was routed through the PL
part.  You can trace it and reroute it for what you want.  Keying was
provided by the PL circuit, which you will have to modify.  Wish I could be
more help, but age sets in about now.  The DC remote is nothing but a small
power supply that puts positive and negative current of 10 ma. on the line
to pull the relays, the multi channel units used 5 ma. to switch
frequencies.  Negative, I believe, would disable the PL for monitoring
purposes.  When you pressed the PTT you put positive on the line, so
polarity was critical.   

73  Jim
de W5JPW

If a radio was first put in service in 1958 would it qualify for QCWA as
well?

This week's project was to bring back a Motorola remote base station
on a local repeater frequency. TRW Amateur Radio Club, 145.320
- 600 KHz with  PL 114.8

TTD6150 transmitter strip. A few miniature tubes, a hand full of locktals,
a 2E26 and that goofy glass bottle with twin plate caps in the final. Not
an 829B, that one was in the mobil units.

TU217 Vibrasender Reed for TX PL.

TRD3150 receiver strip. LOTS of miniature tubes, with a 6U8 and the
volume control sort of cobbled on top of the chassis.

TU333 Vibrasponder Reed for RX PL.

Genuine Motorola "Rock Cod Weight" power supply

Lastly, the DC remote chassis. Oh man, thems some NICE
relay assemblies.

And the whole thing sits in a 3' high indoor cabinet.

A special thanks to M H Electronics for supplying the crystals.

Now, for a few questions.

Anyone got the schematics for these chassis? Specifically the
TRD3150 and TTD6150 chassis.

Anyone know off hand how to disable the RX PL and still
have the carrier squelch work right?

Also, anyone have schematics for the CPI RD11-8 DC Remote?
That's the one that looks like a standard DM-500 desk phone.

As I'm done begging at this point, you're welcome to jump in and
offer any stories you might have regarding this vintage Motorola
stuff.

For example, this unit in particular used to live in a Bob's Big Boy
in Whittier. Although the liscense read "Delivery/dispatch" it was
channeld on the LAPD VHF dispatch frequency.

73 es GE from Jeff
wa6fwi

--- StripMime Report -- processed MIME parts ---
multipart/alternative
  text/plain (text body -- kept)
  text/html
The reason this message is shown is because the post was in HTML
or had an attachment. Attachments are not allowed.
Please post in Plain-Text only.---
_______________________________________________
QCWA mailing list
[email protected]
http://mailman.qth.net/mailman/listinfo/qcwa